Rockwell-automation 1756-CFM ControlLogix Configurable Flowmeter Modul Manual de usuario Pagina 5
- Pagina / 168
- Tabla de contenidos
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
5Rockwell Automation Publication 1756-UM010B-EN-P - December 2011
Table of Contents
Preface
Who Should Use This Manual. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Additional Resources . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Chapter 1
What is the Configurable
Flowmeter Module?
What this Chapter Contains. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Using a ControlLogix
CFM Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Module Features. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Physical Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Typical Applications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Understanding Module Input Capabilities . . . . . . . . . . . . . . . . . . . . . . 15
Understanding Module Output Capabilities . . . . . . . . . . . . . . . . . . . . . 15
Using Module Identification and Status Information. . . . . . . . . . . . . . 16
Chapter 2
Configurable Flowmeter
Operation in the ControlLogix
System
What This Chapter Contains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Ownership . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Using RSNetWorx and RSLogix 5000 . . . . . . . . . . . . . . . . . . . . . . . . . 19
CFM Modules in Local Chassis. . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
CFM Modules in Remote Chassis. . . . . . . . . . . . . . . . . . . . . . . . . . 20
Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Direct Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Listen-Only Connections. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Configurable Flowmeter Modules in a Local Chassis . . . . . . . . . . . . . 23
Requested Packet Interval (RPI). . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Configurable Flowmeter Modules in a Remote Chassis. . . . . . . . . . . . 24
Chapter 3
Configurable Flowmeter Module
Features and Operational Modes
What this Chapter Contains. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Understanding General Module Features . . . . . . . . . . . . . . . . . . . . . . . 25
Removal and Insertion Under Power (RIUP) . . . . . . . . . . . . . . . . 26
Module Fault Reporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Fully Software Configurable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Electronic Keying . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Producer/Consumer Model . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Module Status Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Configurable Flowmetering Channels . . . . . . . . . . . . . . . . . . . . . . 34
Flowmeter Inputs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Gate Inputs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
User-Defined Preset and Rollover Values . . . . . . . . . . . . . . . . . . . 35
Current-Sourcing Outputs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
- User Manual 1
- Important User Information 2
- Summary of Changes 3
- New and Updated 3
- 4 Summary of Changes 4
- Table of Contents 5
- Chapter 4 6
- Installing the Configurable 6
- Table of Contents 7 7
- 8 Table of Contents 8
- Who Should Use 9
- This Manual 9
- Additional Resources 9
- 10 Preface 10
- What this Chapter Contains 11
- Using a ControlLogix 12
- CFM Module 12
- Physical Features 13
- Typical Applications 14
- Understanding Module 15
- Input Capabilities 15
- Output Capabilities 15
- Using Module 16
- Identification and Status 16
- Information 16
- What This Chapter Contains 17
- 1756-CFMLogix controller 18
- Ownership 19
- Using RSNetWorx and 19
- RSLogix 5000 Software 19
- CFM Modules in Local Chassis 20
- CFM Modules in Remote Chassis 20
- Connections 21
- Listen-Only Connections 22
- Configurable Flowmeter 23
- Modules in a Local Chassis 23
- Modules in a Remote 24
- Understanding General 25
- Module Features 25
- Module Fault Reporting 26
- Fully Software Configurable 26
- Electronic Keying 27
- Exact Match 28
- Compatible Keying 29
- Disabled Keying 32
- Producer/Consumer Model 33
- Module Status Information 34
- Flowmeter Inputs 34
- Gate Inputs 34
- Choosing an 35
- Operational Mode 35
- Operating in 36
- High Resolution 36
- Frequency Mode 36
- operate normally 37
- be forced ON or OFF 37
- Low Frequency Clear 38
- Sample Time 38
- Acceleration Calculation 39
- Meter Factor 39
- Trigger On 39
- Tie to Counter 39
- Highest Allowed Frequency 40
- Acceleration Alarm Value 40
- Acceleration 40
- Operating in Totalizer Mode 41
- Using the Totalizer Mode 42
- Using a Prover 43
- Prover Direction 44
- Total Overflow 45
- Total Overrange 45
- Total Overspeed 46
- Total Acceleration 46
- Prover Total 46
- Total Counts 46
- Frequency Period 47
- Gross Volume 47
- Net Volume 47
- Gross Rate 48
- Net Rate 49
- Prover Status 49
- Using the Totalizer 50
- Mode Filler Function 50
- PreTrigger 53
- Fill Mode 53
- Fill Enable 53
- Fill Start 54
- Fill Hold 54
- Fill State 54
- Fill Total 55
- Fill To tal Ta rget 57
- Fill Transition 57
- Fill Transition Timer 57
- Configurable Output 58
- Behaviors 58
- AVERTISSEMENT 62
- Power Requirements 63
- Installing the Module 64
- Keying the Removable 65
- Terminal Block/Interface 65
- Wiring the Removable 66
- Terminal Block 66
- Connect Wires to the RTBs 68
- Wiring the Module 69
- Removing the Removable 74
- Terminal Block from the 74
- Figure 5.2 75
- Removing the Module 76
- Configuring the Configurable 77
- Using this Chapter 78
- Overview of the 78
- Configuration Process 78
- Creating a New Module 80
- Communications Format 82
- Using the Default 83
- Configuration 83
- Altering the Default 84
- Accessing the Tags 85
- Changing Configuration 86
- Information at the Tags 86
- Downloading 87
- Configuration Data 87
- During CFM Module 88
- Operation 88
- Using Message 89
- Instructions 89
- Creating a New Tag 90
- Enter Message Configuration 92
- Communications Pop-Up Screen 93
- Tag Pop-Up Screen 94
- Configuring CFM Modules 95
- Sample Configuration for 101
- Totalizer Mode 101
- Prover Function 101
- Filler Function 108
- Flowmeter Module 115
- Software to Troubleshoot 117
- Your Module 117
- Using RSLogix 5000 117
- Determining Fault Type 118
- Using Error Codes 119
- Software Configuration Tags 121
- Input Tags 128
- Output Tags 132
- Schematics 137
- Output Circuits 139
- 140 Schematics 140
- Frequency Accuracy 141
- Frequency Accuracy in 143
- Frequency Average 145
- 146 Frequency Accuracy 146
- Appendix 147
- Glossary 157
- 158 Glossary 158
- Glossary 159 159
- 160 Glossary 160
- 162 Index 162
- Index 163 163
- 164 Index 164
- Index 165 165
- 166 Index 166
- Rockwell Automation Support 168
- Documentation Feedback 168
Relacionado con productos y manuales para Equipo Rockwell-automation 1756-CFM ControlLogix Configurable Flowmeter Modul
Equipo Rockwell-automation 1734-IM2_IM4 POINT I/O 220V AC Input Module Manual de usuario
(24 paginas)
(24 paginas)
Equipo Rockwell-automation 1757-SWKIT5100 ProcessLogix R510.0 Installation an Manual de usuario
(271 paginas)
(271 paginas)
Equipo Rockwell-automation 1792D2B0LP ArmorBlock LP2 2 Sinking Input Module Manual de usuario
(10 paginas)
(10 paginas)
Equipo Rockwell-automation 1791-XXXX Discrete I/O AC and DC Block I/O Input a Manual de usuario
(98 paginas)
(98 paginas)
Equipo Rockwell-automation 1738-OW4M12AC ArmorPoint Relay Output Modules, Ser Manual de usuario
(14 paginas)
(14 paginas)
Equipo Rockwell-automation 1784-PCMK PCMK Communication Card Installation Man Manual de usuario
(84 paginas)
(84 paginas)
Equipo Rockwell-automation 1756-HYD02 ControlLogix Hydraulic Servo Module Manual de usuario
(98 paginas)
(98 paginas)
Equipo Rockwell-automation 1734-ADN POINT I/O DeviceNet Adapter Quick Start Manual de usuario
(2 paginas)
(2 paginas)
Equipo Rockwell-automation Logix5000 Controllers Controller Information and S Manual de usuario
(59 paginas)
(59 paginas)
Equipo Rockwell-automation 1772-LV,D17726.6.1 A and I MNL MINI-PLC-2/15 PROCE Manual de usuario
(94 paginas)
(94 paginas)
Equipo Rockwell-automation 1793-IB16 Flex Integra Input Module Install Inst Manual de usuario
(12 paginas)
(12 paginas)
Equipo Rockwell-automation 1790D-XXXX DeviceNet 32 Point Digital Base Termina Manual de usuario
(24 paginas)
(24 paginas)
Equipo Rockwell-automation 1771-OWNA Contact Output Module Installation Instr Manual de usuario
(16 paginas)
(16 paginas)
Equipo Rockwell-automation 1746-NO8V SLC 500 8-Point Analog Output Module Manual de usuario
(20 paginas)
(20 paginas)
Equipo Rockwell-automation 1756-RIO ControlLogix Remote I/O (RIO) Communicati Manual de usuario
(28 paginas)
(28 paginas)
Equipo Rockwell-automation 1756-ENET/B ControlLogix Ethernet Communication In Manual de usuario
(122 paginas)
(122 paginas)
© 2020, manymanuals.es. Todos los derechos reservados | 0.189 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales